This story was originally published on RNZ.co.nz and is republished with permission.
Central Auckland's tallest apartment block is yet to get out of the ground because of flawed concrete in its foundations.
The contractor China Construction New Zealand has been struggling to investigate and fix the defects at the Seascape building on Customs Street East for more than a year.
The five-storey-deep walls of the carpark basement have voids in them and are contaminated by slurry.
READ MORE:*Widespread defective or missing concrete or reinforcing steel revealed*Construction firm behind cracked Sydney tower building NZ's tallest residential tower The Pacifica*Weak base being fixed on Seascape, Auckland's tallest apartment building
RNZ
New imaging technology has revealed hundreds of major buildings nationwide have defective or missing concrete or reinforcing steel.
Some concrete on the inside walls of the basement has been waterblasted and patched with structural concrete, but the outer face of the walls is buried in earth and has yet to be properly checked.
The 52-storey Seascape had aimed to open its apartments in 2021, sitting on massive piles, a thick slab, and the basement walls that are well below the level of the sea just 200 metres away.
Auckland Council said it was aware of the risk from seawater getting in and corroding the reinforcing steel.
It had allowed carpark floors to be built only up to a mark five metres below ground level.
"At this point we would not allow work to proceed higher unless we are satisfied that area of wall is compliant," the council said.
The contractorfound defectsand promiseda quick fixback in October 2018 - back then, it said the concrete was "just a bit patchy".
Fourteen months on, Auckland Council is still waiting for key information about the state of the outside face of the walls.
Asked if whole new foundations might be needed, the council said "no", but added if the outside of the walls needed "extensive" repairs, then "other options may be looked at".
It was "anticipated" the outside face of the walls would have the same defects as the inside faces, the contractors and developer said.
But they insisted the defects were isolated, were anticipated, and could be fixed with methods regularly used worldwide.
The walls themselves were being monitored "and these have performed as expected", the contractor and China-owned developer, Shundi Customs, said in a joint statement to RNZ.
However, construction would not begin above ground until the defects were fixed, they said.
"Shundi has dedicated Seascape development as its contribution to Auckland city. With the appointment of reputable contractors and consultants, and under the supervision of local authorities, Seascape aims to deliver a product that is of high standard and quality."
Three of the companies involved with the basement are controlled by the French multinational Vinci.
Sol Expert's findings are in a remediation report prepared by China Construction.
Independent experts were reviewing that report and should provide their assessment by Christmas, the council said.
"We are waiting on further information ... before making a final decision," said the council's manager of field surveying, Jeff Fahrensohn.
"Once we have completed our review we will take any required action deemed necessary to ensure compliance."
It repeated the companies' assertion that the problems were confined to the top five metres of the basement walls, without specifying what evidence it has of this.
The council did not respond to questions about whether any independent investigations had been done on site.
Patching the inside walls had been effective, the council said. "Engineers have certified that the wall's structural integrity has not been compromised.
"Please keep in mind that the D-wall [diaphragm] does not support the tower structure."
Shundi did not say if the timeframe to finish Seascape had changed.
It rejected a comparison with the nearby Hengyi Pacifica tower, that is almost as tall, was started about the same time and was three-quarters finished, with Shundi noting the Pacifica did not have a big basement.
As for near-neighbours of the Seascape, "there is a comprehensive monitoring program in place... at this stage, nothing indicates any compromise to buildings surrounding the site", the council said.
Investigations of the outside faces appears to consist of drilling cores from the inside-out, reducing impacts outside Seascape's footprint. It is unclear how these cores can be drilled far enough through, with so much reinforcing steel in the way.
Freyssinet New Zealand referred RNZ's queries to China Construction.
The building has additional problems: Two piles sunk 29m from ground level into rock, have been built 400mm out of position at the bottom.
The builders are having to thicken the foundation above and add extra anchors to other piles.
The council did not expect to sign off the foundations until late next year.
Also, the tower's fire design has still not been finalised, after two years of wrangling, and being rejected for not giving firefighters enough access in top floors.
A fire design strategy has now been agreed on for when building consent for that stage is lodged.
This story was originally published on RNZ.co.nz and is republished with permission.
Original post:
Council still seeking information on flawed concrete walls of Auckland apartment block - Stuff.co.nz
- Construction begins on 33-story apartment building in downtown St. Pete - St. Pete Rising - February 26th, 2024 [February 26th, 2024]
- Inside Elyria-Swansea's 16-story apartment building that has a plant-filled canyon running through it - Denverite - February 26th, 2024 [February 26th, 2024]
- Here's the status of major apartment projects in Lancaster County - LNP | LancasterOnline - February 26th, 2024 [February 26th, 2024]
- San Diego apartment wave: More than 4000 units opening this year - The San Diego Union-Tribune - February 26th, 2024 [February 26th, 2024]
- Construction marches on for new low-income senior apartments in Colorado Springs - Colorado Springs Gazette - February 26th, 2024 [February 26th, 2024]
- Affordable housing projects take steps toward construction - Your Observer - February 26th, 2024 [February 26th, 2024]
- 'Negligent' engineer whose botched inspection led to NYC apartment building collapse agrees to fine, ban - New York Post - February 26th, 2024 [February 26th, 2024]
- 114 affordable Yesler Terrace units on track for May finish - Seattle Daily Journal of Commerce - February 26th, 2024 [February 26th, 2024]
- Fatalities as fire engulfs apartment blocks in Spain - Construction Briefing - February 26th, 2024 [February 26th, 2024]
- HASTINGS designs two workforce housing complexes in Nashville - The Architect's Newspaper - February 26th, 2024 [February 26th, 2024]
- Cladding under suspicion as four die in Valencia tower blaze - Global Construction Review - February 26th, 2024 [February 26th, 2024]
- Construction begins on new apartment building coming to Norwood in 2025 - News 12 Bronx - February 16th, 2024 [February 16th, 2024]
- NYC Building Permits Spike But Only for Homes, Not Apartments - Commercial Observer - February 16th, 2024 [February 16th, 2024]
- Nine states pledge to transition to heat pumps for residential HVAC and water heating - Building Design + Construction - February 16th, 2024 [February 16th, 2024]
- Construction to begin on 164-unit affordable housing property in Rosemount - St. Paul Pioneer Press - January 5th, 2024 [January 5th, 2024]
- Construction on a new apartment complex to begin in Fox Lake - WiscNews - January 5th, 2024 [January 5th, 2024]
- Park Slope's Grand Prospect Hall-Replacing Build Hits Snags - Brownstoner - January 5th, 2024 [January 5th, 2024]
- Crews Quickly Put Out Brush Fire Near Apartment Building Under Construction - Times of San Diego - January 5th, 2024 [January 5th, 2024]
- Construction to begin on Lawrence apartments in Buffalo - Buffalo News - January 5th, 2024 [January 5th, 2024]
- Austin Rents Fall as Apartment Construction Accelerates - Planetizen - January 5th, 2024 [January 5th, 2024]
- Construction of 190-apartment residential neighborhood in Sugovushan continues [PHOTOS] - AzerNews.Az - January 5th, 2024 [January 5th, 2024]
- The Mill at Prattville's historic downtown gin shop wraps construction - Montgomery Advertiser - January 5th, 2024 [January 5th, 2024]
- Tempe residents will see 4 new high-rise apartments take shape in 2024 - The Arizona Republic - January 5th, 2024 [January 5th, 2024]
- Crane Watch: Apartments, apartments and more apartments being built as multifamily sector booms in Austin - The Business Journals - January 5th, 2024 [January 5th, 2024]
- 10 new Detroit developments to get excited about in 2024 - Detroit Free Press - January 5th, 2024 [January 5th, 2024]
- Developer hopes to have prefab apartments in seven CT towns - Hartford Courant - January 5th, 2024 [January 5th, 2024]
- Apartment building destroyed after fire in Southeast Fresno - KMPH Fox 26 - April 5th, 2023 [April 5th, 2023]
- Commercial and Multifamily Construction Starts Post Solid Recovery in 2021 - Construction.com - January 25th, 2022 [January 25th, 2022]
- More high-end apartments on the way at Tobin estate as second phase of construction starts - San Antonio Express-News - January 25th, 2022 [January 25th, 2022]
- 49-unit WDM affordable apartment project expected to be completed by fall - Business Record - January 25th, 2022 [January 25th, 2022]
- Construction of Willow Valley Communities' 20-story downtown building to begin after sales of its apartments - LNP | LancasterOnline - January 25th, 2022 [January 25th, 2022]
- New Zealands bipartisan housing reforms offer a model to other countries - Brookings Institution - January 25th, 2022 [January 25th, 2022]
- HDC Hyundai Development raided in connection with Gwangju apartment building collapse - The Korea Herald - January 25th, 2022 [January 25th, 2022]
- Bend's big shift from single-family homes to more multifamily housing tops city's expectations - KTVZ - January 25th, 2022 [January 25th, 2022]
- New Construction Is Not Always the Answer - ArchDaily - January 25th, 2022 [January 25th, 2022]
- Boston-based boutique hotelier buys Wilton Manors apartment building for $8M - The Real Deal - January 25th, 2022 [January 25th, 2022]
- Miami Mayor Francis Suarez Says City Is Growing Faster Than Ever At Panel Discussion With Developers - CBS Miami - January 25th, 2022 [January 25th, 2022]
- These Will Be the Hottest Up-and-Coming NoVA Neighborhoods in 2022 - northernvirginiamag.com - January 25th, 2022 [January 25th, 2022]
- Downtown DeLand CRA throws big incentive to apartment developer - The West Volusia Beacon - January 25th, 2022 [January 25th, 2022]
- Why a 4-storey apartment could be coming to a residential street near you - CBC.ca - January 25th, 2022 [January 25th, 2022]
- He Was in Witness Protection in Maine. But His Harlem Life Kept Calling. - The New York Times - January 25th, 2022 [January 25th, 2022]
- NYCs Wealthy Enclaves Lost Housing in Past Decade as Combining of Apartments Outpaced New Construction - THE CITY - February 9th, 2021 [February 9th, 2021]
- Holladay planning $27M apartment project in Fletcher Place by former Milano Inn - Indianapolis Business Journal - February 9th, 2021 [February 9th, 2021]
- Building construction price indexes, Q4 2020 - Lumber still an issue - Electrical Business - Electrical Business - February 9th, 2021 [February 9th, 2021]
- WHATS THIS? ANOTHER 50+ AFFORDABLE APARTMENTS UNDER CONSTRUCTION - Florida Keys Weekly - February 9th, 2021 [February 9th, 2021]
- 538 new houses, condos and apartments proposed on Ann Arbors north side - MLive.com - February 9th, 2021 [February 9th, 2021]
- 7-story building with parking garage, restaurant and apartments to be built near new courthouse in Harrisburg - PennLive - February 9th, 2021 [February 9th, 2021]
- Developer of in-progress $31M housing project in Williamsville seeks tax breaks - Buffalo News - February 9th, 2021 [February 9th, 2021]
- Downtown Vancouver is on the rise - The Columbian - February 9th, 2021 [February 9th, 2021]
- Demolition in Ohio City signals big visible first step toward creation of park at Irishtown Bend - cleveland.com - February 9th, 2021 [February 9th, 2021]
- Developer closes on financing for $124M apartment project in West St. Paul - TwinCities.com-Pioneer Press - February 9th, 2021 [February 9th, 2021]
- Apartment Developers Increasing Unit Sizes For New Projects In Response To Pandemic - Bisnow - February 9th, 2021 [February 9th, 2021]
- A makeover for Norfolks deluxe apartment in the sky - WAVY.com - February 9th, 2021 [February 9th, 2021]
- Teacher housing plan moves ahead in Palo Alto - Palo Alto Online - February 9th, 2021 [February 9th, 2021]
- Guilderland and Pyramid seek to reverse ruling that halted companys projects - The Altamont Enterprise - February 9th, 2021 [February 9th, 2021]
- Another South U block demolished to make way for next Ann Arbor high-rise - MLive.com - January 3rd, 2021 [January 3rd, 2021]
- The Pandemic Disproved Urban Progressives Theory About Gentrification - The Atlantic - January 3rd, 2021 [January 3rd, 2021]
- The Sydney apartment tribes reshaping the harbour city - Sydney Morning Herald - January 3rd, 2021 [January 3rd, 2021]
- Editorial: Changes needed to build more middle-income housing - The Daily Herald - January 3rd, 2021 [January 3rd, 2021]
- 1 dead in 4-alarm Yonkers apartment building fire - Yahoo News - January 3rd, 2021 [January 3rd, 2021]
- ATF helping to investigate massive fire at Waldo Heights apartments - KMBC Kansas City - January 3rd, 2021 [January 3rd, 2021]
- With little effect on ground, work on Minneapolis 2040 plan continues behind the scenes - Minneapolis Star Tribune - January 3rd, 2021 [January 3rd, 2021]
- Construction of housing project for the elderly begins in Dupont - Insurance News Net - January 3rd, 2021 [January 3rd, 2021]
- COVID will leave lasting changes in Minnesota office and apartment projects - Minneapolis Star Tribune - December 23rd, 2020 [December 23rd, 2020]
- Three-story office building proposed to slide in between apartments, alley in Downtown Boise - boisedev.com - December 23rd, 2020 [December 23rd, 2020]
- US apartment construction boosts housing supply in November - Yahoo News - December 23rd, 2020 [December 23rd, 2020]
- Looking ahead: Fishers major projects in 2021 include the Nickel Plate Trail tunnel and First Internet - Current in Carmel - December 23rd, 2020 [December 23rd, 2020]
- Downtown development to focus on apartments | News - Bowling Green Daily News - December 23rd, 2020 [December 23rd, 2020]
- Developer Who Almost Landed Amazon HQ2 Planning Scores Of Apartments In Its Place - Bisnow - December 23rd, 2020 [December 23rd, 2020]
- Avenue breaks ground on 34th Street apartment complex - The Leader - December 23rd, 2020 [December 23rd, 2020]
- Hayle Harbour development celebrates milestone with topping out ceremony - In Your Area - December 23rd, 2020 [December 23rd, 2020]
- Here are 2020s most active architects - The Real Deal - December 23rd, 2020 [December 23rd, 2020]
- Apartments planned along Columbia River between Camas, Washougal - The Columbian - December 23rd, 2020 [December 23rd, 2020]
- Building law reform for NSW residential apartment buildings: Beware builders and developers - Real Estate and Construction - Australia - Mondaq News... - December 10th, 2020 [December 10th, 2020]
- Clean Air: The Next Luxury Apartment Perk - The Wall Street Journal - December 10th, 2020 [December 10th, 2020]
- Mill Creek Begins Construction on Washington, DC-Area Community - Multi-Housing News - December 10th, 2020 [December 10th, 2020]
- AvalonBay buys Somerville site from Somerset Development, ready to build apartments and more in transit-oriented development - ROI-NJ.com - December 10th, 2020 [December 10th, 2020]
- Mitch McConnell urges Senate to pass the $741 billion defense bill Trump has vowed to veto - Business Insider India - December 10th, 2020 [December 10th, 2020]
- A Couple Explore the Towers of Long Island City. Which of These Apartments Would You Choose? - The New York Times - December 10th, 2020 [December 10th, 2020]
- KWA Construction Tops Out 293-Unit Upscale Waterfront Apartment Community in Las Colinas Area of Irving, Texas - MultifamilyBiz.com - December 10th, 2020 [December 10th, 2020]